To the content
5 . 2017

Optimization of microbiological methods for food control based on the differential-diagnostic media for the isolation and cultivation of bacteria of the genus Campylobacter

Abstract

А screening study on the detection of campylobacteria in raw food products, semi-finished products and objects in the external environment in the poultry processing industry was conducted. The highest level of detection of campylobacteria is set for raw poultry products, including carcasses of broilers, turkeys and quail. A general accordance of getting Campylobacter in raw materials and food products with inadequate sanitary treatment of separate areas of production has been established: in most cases Campylobacter spp. was extracted from the samples, contaminated with coliform bacteria and Salmonella. It is shown that the frequency of contamination of raw poultry with pathogens is largely dependent on the cooling of the carcasses. When using the immersion method, the conditions for cross contamination with pathogens through water bath cooling are present (45% of samples infected with Campylobacter spp.). Under combined use of super-cooled water and aerosols Campylobacter were also detected quite often in 27% of samples. Contamination by pathogens was the lowest in evaporative cooling method with the use of antimicrobial hydrospray (less than 5% positive samples), allowing to recognize this method as the most promising for the production of microbiological safe products. The work on optimization of nutrient medium composition and adaptation recommended methodological scheme of analysis for detection and species identification of bacteria of the genus Campylobacter was carried out. Formulation of traditionally used growth media was modified, and balanced composition of growth and selective components was matched in accordance with the requirements of existing standards. Given the urgency of increasing the effectiveness of the methods of control of campylobacteria in foods and the lack of domestic analogues of the culture media in the Russian Federation, an optimized method for the production of dry nutrient media for the detection, identification and storage of campylobacteria isolated from food products and clinical material was developed. The conducted study allowed to develop Technical conditions 21.20.23-006-01897222-2016 «Dry culture medium for detection of bacteria of the genus Campylobacters and «Instruction for use of culture media». Depending on the purpose of the medium produced in the following versions: the selective broth for enrichment of campylobacteria; differential selective agar for isolating and quantifying of Campylobacter spp.; semi-solid nutrient agar for cryostorage of Campylobacter strains. The list of criteria for assessing the quality of commercially available lots of dry media included: solubility, pH, gel strength of agar, the content of amine nitrogen, specificity, selectivity, growth and inhibitory properties. The practical application of these media in terms of the national laboratories will significantly simplify the use of existing standards developed based on international ISO standards, but not adapted to the main range of commercial media and reagents used in routine food control for the presence of campylobacteria.

Keywords:bacteria of the genus Campylobacter, culture media, food products, methods of control, storage of strains

Problems of Nutrition. 2017; 86 (5): 34-41. doi: 10.24411/0042-8833-2017-00074.

All articles in our journal are distributed under the Creative Commons Attribution 4.0 International License (CC BY 4.0 license)

SCImago Journal & Country Rank
Scopus CiteScore
CHIEF EDITOR
CHIEF EDITOR
Viktor A. Tutelyan
Full Member of the Russian Academy of Sciences, Doctor of Medical Sciences, Professor, Scientific Director of the Federal Research Centre of Nutrition, Biotechnology and Food Safety (Moscow, Russia)

Journals of «GEOTAR-Media»