To the content
5 . 2020

Ways of nutritional value increasing of distillary grain fiber

Abstract

In the process of grain processing for ethyl alcohol, practically only carbohydrates are consumed, which are presented mainly in the form of starch. The remaining components (protein, fats, fiber, minerals) in transit pass into the grain fiber remaining after distillation of the alcohol from the mash. Distillery grain fiber surpasses wheat bran in its indicators, since during the processing it is enriched with biomass of alcohol yeast. In addition, there is a technological possibility of its additional enrichment with protein, amino acids, and vitamins due to changes in the modes of alcoholic fermentation.

The aim of the work was to assess the influence of the mode and conditions of alcoholic fermentation on the composition of distillery grain fiber.

Material and methods. Under laboratory conditions, samples of grain fiber of alcohol production were obtained by the method of fermentation samples from wheat under various fermentation conditions. In the obtained samples, the following parameters were determined: protein according to Barnstein, crude protein, vitamins B1, B2, B6, E, as well as the amino acid composition. The volume fraction of ethyl alcohol, the mass concentration of fermentable carbohydrates, and the concentration of yeast cells were determined in intermediate products of alcohol production.

Results and discussion. Studies on the effect of yeast from various manufacturers on fermentation rates, biomass growth and grain fiber composition showed the advantage of race Y-717 in terms of alcohol accumulation (11.5% vol.), Fermentation rate (56 hours) and yeast cell concentration (260 million/cm3), which was 15-30% more than in other options. However, from the point of view of increasing the content of protein according to Barnstein and crude protein in samples of grain fiber with yeast Y-717, an increase of only 3-4% was noted compared with other options. This was associated with a decrease in the concentration of yeast by 72 h of fermentation due to autolysis. Studies on the influence of the initial yeast concentration on the growth of biomass, the fermentation rate and grain fiber indices showed that with an increase in the initial yeast concentration from 15 to 45 million/cm3, the fermentation time reduced to 48 h, the biomass growth at the end of fermentation was 20%, the protein in grain fiber increased by 15%, the content of vitamins B1, B2, B6 and E as well as amino acids increased by 13-17%.

Conclusion. According to the results of the studies, the technological possibility of enriching distillery grain fiber with protein, amino acids, and vitamins due to a change in the fermentation process during the processing of grain raw materials to alcohol is shown. In particular, this could be achieved through the use of yeast with a high growth rate, by increasing the concentration of yeast biomass, shortening the fermentation period and preventing yeast autolysis at the maturation stage.

Keywords:dietary fiber, distillery grain fiber, yeast biomass, crude protein, amino acids, vitamins

Fundng. Research work on the preparation of the manuscript was carried out at the expense of the state task grant (No. 0529-2019-0066).

Conflict of interest. The authors declare no conflict of interests.

For citation: Abramova I.M., Bessonov V.V., Bogachuk M.N., Krivchenko V.A., Makarenko M.A., Sokurenko M.S., Solovyov A.O., Turshatov M.V., Shevyakova L.V. Ways of nutritional value increasing of distillary grain fiber. Voprosy pitaniia [Problems of Nutrition]. 2020; 89 (5): 110-8. DOI: https://www.doi.org/10.24411/0042-8833-2020-10071 (in Russian)

References

1. Pyr’eva E.A., Safronova A.I. The role and place of dietary fiber in the nutritional structure of the population. Voprosy pitaniia [Problems of Nutrition]. 2019; 88 (6): 5–11. DOI: https://doi.org/10.24411/0042-8833-2019-10059(in Russian)

2. So D., Whelan K., Rossi M., Morrison M., Holtmann G., Kelly J.T., et al. Dietary fiber intervention on gut microbiota composition in healthy adults: a systematic review and meta-analysis. Am J Clin Nutr. 2018; 107 (6): 965–83. DOI: https://doi.org/10.1093/ajcn/nqy041

3. Gibson R., Eriksen R., Chambers E., Gao H., Aresu M., Heard A., et al. Intakes and food sources of dietary fibre and their associations with measures of body composition and inflammation in UK adults: cross-sectional analysis of the airwave health monitoring study. Nutrients. 2019; 11 (8): E1839. DOI: https://doi.org/10.3390/nu110818393

4. Davison K.M., Temple N.J. Cereal fiber, fruit fiber, and type 2 diabetes: explaining the paradox. J Diabetes Complications. 2018; 32 (2): 240–5. DOI: https://doi.org/10.1016/j.jdiacomp.2017.11.002

5. Ardatskaya M.D. Clinical use of dietary fiber: Methodological manual. Moscow: 4TE Art, 2010: 48 p. (in Russian)

6. Jonsson K., Andersson R., Bach Knudsen K.E., Hallmans G., Hanhineva K., Katina K., et al. Rye and health – where do we stand and where do we go? Trends Food Sci Technol. 2018; 79: 78–87. DOI: https://doi.org/10.1016/j.tifs.2018.06.018

7. Soliman G.A. Dietary fiber, atherosclerosis, and cardiovascular disease. Nutrients. 2019; 11 (5): 1155. DOI: https://doi.org/10.3390/nu11051155

8. O’Keefe S.J. The association between dietary fibre deficiency and high-income lifestyle-associated diseases: Burkitt’s hypothesis revisited. Lancet Gastroenterol Hepatol. 2019; 4 (12): 984–96. DOI: https://doi.org/10.1016/S2468-1253(19)30257-2

9. Kobel’kova I.V., Martinchik A.N., Kudryavtseva K.V., Baturin A.K. Diet in maintaining the health of the working population. Voprosy pitaniia [Problems of Nutrition]. 2017; 86 (5): 17–21. DOI: https://doi.org/10.24411/0042-8833-2017-00071 (in Russian)

10. Tutelyan V.A., Nikityuk D.B., Buryak D.A., Akol’zina S.E., Baturin A.K., Pogozheva A.V., et al. Atlas: Quality of Life. Health and Nutrition. Moscow: Meditsina, 2018: 696 p. (in Russian)

11. Skurikhin I.M., Tutelyan V.A. (eds) The Chemical Composition of Russian Food Products: A handbook. Moscow: DeLi print, 2002: 236 p. (in Russian)

12. Composition of Foods Raw, Processed, Prepared. USDA National Nutrient Database for Standard Reference. Maryland: U.S. Department of Agriculture, 2019.

13. Puligundla P., Mok C., Park S. Advances in the valorization of spent brewer’s yeast. Innov Food Sci Emerg Technol. 2020; 62: 102350. DOI: https://doi.org/10.1016/j.ifset.2020.102350

14. Jach M.E., Serefko A., Sajnaga E., Kozak E., Poleszak E., Malm A. Dietary supplements based on the yeast biomass. Curr Top Nutr Res. 2015; 13 (2): 83–8.

15. Holban A.M., Grumezescu A.M. (eds) Diet, Microbiome and Health. 2018: 526 p. DOI: https://doi.org/10.1016/C2016-0-00475-8

16. Amorim M., Marques C., Pereira J.O., Guardão L., Martins M.J., Osório H., et al. Antihypertensive effect of spent brewer yeast peptide. Process Biochem. 2019; 76: 213–8. DOI:https://doi.org/10.1016/j.procbio.2018.10.004

17. Campagnollo F.B., Khaneghah A.M., Borges L.L., Bonatob M.A., Fakhri Y., Barbalhob C.B., et al. In vitro and in vivo capacity of yeast-based products to bind to aflatoxins B1 and M1 in media and foodstuffs: a systematic review and meta-analysis. Food Res Int. 2020; 137: 109505. DOI: https://doi.org/10.1016/j.foodres.2020.109505

18. Williams R., Dias D.A., Jayasinghe N., Roessner U., Bennett L.E. Beta-glucan-depleted, glycopeptide-rich extracts from Brewer’s and Baker’s yeast (Saccharomyces cerevisiae) lower interferon-gamma production by stimulated human blood cells in vitro. Food Chem. 2016; 197 (A): 761–8. DOI: https://doi.org/10.1016/j.foodchem.2015.11.015

19. Bessonov V.V., Bogachuk M.N., Makarenko M.A., Sokurenko M.S., Shevyakova L.V., Abramova I.M., et al. Study of the biochemical composition of grain fiber alcohol production. Pishchevaya promyshlennost'. 2020; (2): 12–5. DOI: https://doi.org/10.24411/0235-2486-2020-10014(in Russian)

20. Polyakov V.A., Abramova I.M., Polygalina G.V., Rimareva L.V., Korchagina G.T., Piskareva E.N. (eds) Instructions for Technological and Microbiological Control of Alcohol Production. 7th ed. rev. and add. Moscow: DeLi print, 2007: 480 p. (in Russian)

21. R 4.1.1672-03 Guidance on Methods for Monitoring the Quality and Safety of Dietary Supplements. Moscow Federal Center for State Epidemiological Surveillance of the Ministry of Health of Russia, 2004: 240 p. (in Russian)

All articles in our journal are distributed under the Creative Commons Attribution 4.0 International License (CC BY 4.0 license)

SCImago Journal & Country Rank
Scopus CiteScore
CHIEF EDITOR
CHIEF EDITOR
Viktor A. Tutelyan
Full Member of the Russian Academy of Sciences, Doctor of Medical Sciences, Professor, Scientific Director of the Federal Research Centre of Nutrition, Biotechnology and Food Safety (Moscow, Russia)

Journals of «GEOTAR-Media»